E39 series BMW 5

since 1996-2001 of release

Repair and car operation



E39 BMW
+ Introduction
- Maintenance instruction
   Governing bodies, devices and control lamps
   Locking devices and anticreeping alarm system
   Salon equipment
   Safety systems
   Fuel filling, start and engine stop
   Parking brake
   Manual box of gear shifting (RKPP)
   Automatic transmission (AT) *
   Tempostat
   The alarm system of emergency rapprochement at a parking (PDC) *
   System of automatic stabilization of stability with a regulator of traction effort (ASC+T)
   Electronic adjustment of rigidity of amortization (EDC) * and adjustment of a road gleam
   Lighting
   Heating and ventilation system
   Automatic кондиционер*
   Independent systems of heating and ventilation
   System самодиагностики*
   Traveling computer
   Running in
   Catalytic converter
   Anti-blocking system of brakes (ABS)
   Movement with the trailer
   Luggage carrier on a roof
   Automobile телефон*
   Radio reception
   Readjustment of headlights
   Cowl
   Automobile radio receiver
   Hi-Fi type audiosystem with DSP*
   Sign emergency остановки*
   Аптечка*
+ Current leaving and service
+ Engine
+ Systems of cooling, heating
+ Power supply system and release
+ engine Electric equipment
+ Manual transmission
+ Automatic transmission
+ Coupling and power shafts
+ Brake system
+ Suspension bracket and steering
+ Body
+ Onboard electric equipment
+ electric equipment Schemes
+ System of onboard diagnostics





Governing bodies, devices and control lamps

Governing bodies and devices

* the asterisk in this Section marked special autoaccessories, elements of the additional equipment or a complete set of export models. All models and all types of the complete set are described, which BMWs offers the consumer.

Description

1.

light switch (Section Lighting)

2.

the switch of indexes of turn (further in this Section)
parking fires (Section Lighting)
driving beam (Section Lighting)
light signal (Section Lighting)
managements traveling компьютером* (Undressed the Travelling computer)

3.

switch of antifog devices of lighting (Section Lighting)

4.

the lever of the switch of system of screen wipers / стеклоомывателей (further in this Section)

5.

the button of system of the uniform lock (Undressed Locking devices and the anticreeping alarm system)

6.

the button of inclusion of system of the alarm light system (further in this Section)

7.

key of inclusion of heating of back glass (further in this Section)

8.

sound signal, all panel

9.

the lever of the switch of electroadjustment of the helmsman колеса* (Undressed the salon Equipment)

Depending on a complete set on the car one of two options of an instrument guard is established.

Control panel. Option of execution 1

Control panel. Option of execution 2

Description

1.

the index of a stock of fuel with a control lamp of a reserve

2.

control lamps of indexes of turns

3.

speedometer

4.

control lamp of a driving beam

5.

tachometer and эконометр

6.

the index of temperature of cooling liquid with an alarm lamp “Too high temperature of cooling liquid”

7.

control and alarm lamps:
- parking brake
- ABS
- level brake liquid / wear of brake shoes
- inflatable safety cushions
- темпостата
- reminders on need пристегнуться*
- АТ*

8.

position of the lever of the selector and the indicator of the chosen program of gear shifting for AT* (The section Automatic transmission (AT) *)

9.

indicator of the forthcoming maintenance

10.

display of the indicator of temperature of external air and traveling компьютера*:
average fuel consumption the rough stock of a course and average speed - management from the switch of indexes of turn, Undressed the Travelling computer.

11.

control lamp of a regulator road просвета*

12.

control lamp of system of automatic stabilization of stability with adjustment of traction effort of ASC+Т*

13.

the counter of the general run and run measuring instrument from the moment of dumping

14.

display of system automatic диагностики* (Section self-diagnostics System *)

15.

button of dumping of indications of a measuring instrument of run

16.

control and alarm lamps
- antifog фар*
- back foggy фонарей*
- oil level in the engine
- accumulator category
- pressure of oil in the engine
- преднакала* / digital electronic control system of the diesel engine (DDE) *

17.

control and alarm lamps:
- parking brake
- level brake liquid / wear of brake shoes
- ABS
- inflatable safety cushions
- темпостата
- reminders on need пристегнуться*

18.

button of a call of indications of system of automatic diagnostics
(Section self-diagnostics System *)

19.

control lever and the indicator of the chosen program of gear shifting for AT* (The section Automatic transmission (AT) *)

20.

indicator of temperature of external air

21.

the display of system of automatic diagnostics, the traveling computer and - at equipment by a multipurpose steering wheel - also a radio receiver and phone (The section self-diagnostics System *)

22.

Control and alarm lamps antifog фар*
back foggy фонарей*
accumulator category
pressure of oil in the engine

Control and alarm lamps

Working capacity check

The control and alarm lamps marked with a sign "-", light up for some time with a view of working capacity check from the moment of ignition key turn in situation 2 and die away practically at once after engine start-up.

 WORKING CAPACITY CHECK

Turn index, green
The lamp blinks at inclusion of indexes of turn. At movement with the trailer the lamp blinks also at inclusion of indexes of turn on the trailer. The speeded-up blinking testifies to defect in system.

Driving beam, dark blue
The lamp burns at the included driving beam and using a light signal. For details address to the Section Lighting.

The parking brake, red -
The lamp lights up at the tightened lever of the parking brake. For details address to the Section the Parking brake.

Level brake liquid/wear of brake shoes *, red -
At fire of a lamp it is necessary to check level of brake liquid or a condition of brake shoes. If level of brake liquid fell below norm (on the display of system of automatic diagnostics there is a message “Bremsflüssigk. prüfen”
or
Brake shoes wore out (on the display of system of automatic diagnostics there is “Bremsbelag prüfen" message)

Anti-blocking system of brakes (ABS), yellow -
If the lamp lights up during movement, it serves as a signal of shutdown of ABS because of malfunction of system. Thus normal efficiency of brakes remains without restrictions. Address for check on STOA BMW. For details address to the Section Anti-blocking system of brakes (ABS).

Inflatable safety cushions, red -
Check of operability of a lamp is made after ignition key turn in situation 1. If thus it does not light up or lights up during movement, the request to address on STOA BMW for check. For details address to the Section of System of safety.

Tempostat *, green
The lamp burns at the included system. The system can be operated from a multipurpose steering wheel. For details address to the Section Tempostat.

Please, be fastened *, red -
Depending on a car complete set at fire of a lamp are possible simultaneous giving sound сигнала* or emergence сообщения* on the display of system of automatic diagnostics. Depending on a car complete set the lamp burns up to a pristegivaniye. For details about seat belts address to materials of the Section of System of safety

Automatic transmission *, yellow ­
Because of malfunction of AT of gear shifting are carried out only according to the emergency program. The request to address on the next STOA BMW. For details address to the Section Automatic transmission (AT) *.

Regulator of a road gleam *, yellow ­
If the control lamp lit up or on the display of system of automatic diagnostics there was “Niveauregel inaktiv” message, it means that the regulator of a road gleam is faulty.
Stop and examine the car. If its back part is located much below a lobby, or the car costs slantwise (compare right back and left back parts), address on the next STOA BMW. Carefully continue movement.

ASC+Т stability Stabilization with adjustment of traction effort, yellow ­
The system is disconnected as a result of pressing of a key or because of malfunction. At malfunction emergence a request to address on STOA BMW. For details address to the Section System of automatic stabilization of stability with a regulator of traction effort (ASC+T).

Fog lights *, green
The lamp burns at the included fog lights. For details address to the Section Lighting.

Back foggy lamps *, yellow
The lamp burns at the included back foggy lamps. For details address to the Section Lighting.

Oil level in the engine *, yellow
At fire of a lamp check oil level. For details address to the Section Check of levels of liquids.

Accumulator category, red ­
Fire of a lamp serves as a signal about lack of a battery charging. Defect of a maple belt in a drive of the generator or violation of a chain of a charging current in the generator can be the reason.
To continue movement it is impossible, as there is a danger of damage of the engine as a result of its overheat. At defect of a maple belt the effort which is necessary for putting to a steering wheel when driving increases.

Pressure of oil in the engine, red ­
If the lamp lights up under way the car with simultaneous emergence of the message “Stop! Oldruck Motor” (Stop! In the engine) on the display of system automatic диагностики* (if the car is equipped with this system), it is necessary to stop, muffle pressure of oil at once the engine to check level of oil and if necessary to finish it to norm. If level appears in norm, address for consultation on STOA BMW.
To continue movement it is impossible, as there is a danger of damage of the engine as a result of insufficient greasing.

Preheat of candles of an incandescence *, yellow ­
To start the engine it is possible only after the lamp will go out. For details address to the Section fuel Filling, start and an engine stop. If during movement the alarm lamp of DDE system lit up or on the display of system of automatic diagnostics there was “Einspritzanlage” message, it means that in electronic system of injection there was a malfunction. If the engine did not decay, it is possible to continue movement as management of operation of the engine will be carried out according to the emergency program. However thus the capacity will be reduced. Therefore at the first possibility repair injection system.

Run counters, indicator of temperature of external air

Execution of counters and the indicator variously depending on a complete set of your car.

Counter of the general run

At ignition key installation in situation 0 you can cause counter indications on indication by button pressing on an instrument guard (it is shown by an arrow).

Run measuring instrument from the moment of dumping

Dumping on a zero occurs by pressing of the button shown by an arrow if thus the ignition key is in situation 1 or 2.

Indicator of temperature of external air

Since key installation in situation 1, on indication the temperature of external air is deduced. A conclusion to indication at switched off зажигании*: press the button.

Prevention of ice

At temperature drop below +3°С the warning sound signal, and indication some time is distributed blinks.

The prevention repeats, if after the last giving of a signal the temperature at least rose once to +6°С, and then again fell to +3°С.

Despite existence of system of the prevention of ice, possibility of its education (for example, on bridges and the shaded sites of roads) as well is not excluded at temperature above +3°С.

Tachometer

Avoid finishing of turns of the engine to values of red sector of a scale.
In this range for protection of the engine supply of fuel that is appreciable by capacity falling interrupts.

Ekonometr

Ekonometr registers the actual fuel consumption in km l/100. You can supervise at any time, your manner of driving is how economic and harmless.
At a stop of the car of the shooter comes back to a zero.

The index of a stock of fuel in a tank

For check of operation of the device its control lamp for some time lights up at ignition inclusion.
If the lamp burns constantly, it means that in a tank there was the following amount of fuel:
about 8 l - BMW 520i, 523i, 528i, 525tds
about 10 l - BMW 535i, 540i
Data on refueling capacity of a fuel tank are presented in Specifications.

The various tilt angle of the car (for example, at long movement on the mountain road) can cause insignificant fluctuations of instrument readings.
The request to refuel in due time as driving “to a last straw” can lead to engine or catalyst damages.

The index of temperature of cooling liquid

Arrow on dark blue sector
Engine still the cold. Movement should occur at moderate turns and speeds.
Arrow on red sector
If the control lamp blinks or on the display automatic диагностики* there is “Kuhlwassertemperatur” message (Temperature of cooling liquid), it means that the engine перегрет. In this case it is necessary at once to stop and allow to the engine to cool down.

Scale zone between color sectors
Corresponds to normal working temperature. At high temperature of external air or at big loads of the engine of the shooter can come nearer to red sector closely.
Check of level of cooling liquid is carried out according to Section recommendations Check of levels of liquids.

Indicator of the forthcoming maintenance

Indicator execution variously depending on a komlektatsiya of your car.

Green signals
The remains being shone green signals less, the maintenance term is closer.
Yellow signal
This signal appears in a combination to OILSERVICE or INSPECTION messages. Lights up at approach of term of the corresponding maintenance.
Red signal
Term next THAT is passed.
Symbol in the form of hours
Reminder on approach of term of replacement of brake liquid.

The indicator does not consider time of parking of the car with the disconnected plugs of the accumulator.

However for observance of the established periodicity of replacement of brake liquid it is necessary to consider this time.

Switch of indexes of turn and driving beam

The switch has the following working provisions:
1 — the Driving beam (after inclusion the dark blue control lamp burns)
2 — the Light signal
3 — turn Indexes (after inclusion the green control lamp blinks and the relay clicks)

The speeded-up blinking of a control lamp and clicking of the relay serve as a signal about malfunction of one of lamps of indexes of turn (at movement with the trailer - malfunction of a lamp of the index of turn on the trailer is possible also).

Unstable inclusion of indexes of turn
Slightly press on the lever, without translating it for a point of the increased resistance. If to release the switch lever, he will return to a starting position.

Screen wipers and stekloomyvatel

0 — a starting position (screen wipers do not work)
1 — work of screen wipers in interval the intensity mode/sensor дождя*
2 — work of screen wipers with normal rate
3 — work of screen wipers with the increased frequency
4 — single inclusion of screen wipers
5 — work of stekloomyvatel in an automatic mode
6 — work of stekloomyvatel in intensive режиме*
7 — a regulator of an interval of inclusion of screen wipers at work in interval mode / sensitivity of the sensor of intensity of a rain

1. Interval mode / sensor of intensity дождя*

The interval between inclusions can be regulated in steps by the corrugated castor 7 having four situation. Besides, there is an automatic control depending on the actual speed of movement.

Sensor of intensity of a rain

The sensor allows to regulate automatically frequency of work of screen wipers depending on intensity of a rain and, certainly, snowfall. It means that if you turned on the sensor, you should not care of inclusion any more both switching off of screen wipers and switching from one mode of their work on another. You can concentrate the attention to the road completely. It is especially convenient under bad weather conditions.

The radiator directs infra-red light on a windscreen surface in such a manner that at dry glass this light is reflected completely. The sensor measures intensity of reflected light.

If glass is covered with water drops, extent of reflection decreases, as infra-red light partially passes through glass. Intensity of reflected light allows to define extent of moistening of a windscreen.

If screen wipers are included in an interval mode, they react at once, if, for example, on a windscreen of your car water from under wheels ahead of the going car got. Thus, the sensor of intensity of a rain promotes bigger traffic safety and increase of convenience of driving.

Turning on of the sensor

 PERFORMANCE ORDER

1. After ignition key turn in situation 1 or 2 transfer the switch lever from situation 0 to situation 1. In any case as confirmation of turning on of the sensor there will be a single operation of screen wipers.
2. You can turn on also the sensor, having transferred the switch lever to situation 1 of any other situation or having involved automatic (5) or an intensive mode (6) in position of 1 switch
3. The corrugated castor 7 will allow you to regulate sensitivity of the sensor according to your wishes.
4. Switching off of ignition conducts to sensor shutdown.

If you want to leave for a long time the switch lever in situation “Sensor of intensity of a rain”, after ignition key turn you can turn on the sensor in situation 1, having turned a corrugated castor 7.

At a sink in the jet washer disconnect the sensor as inadvertent operation of screen wipers can lead to their breakage.

2. Work of screen wipers with normal rate

At a stop of the car there is an automatic switching on an interval operating mode (it does not belong to cars with the sensor of intensity of a rain).

3. Work of screen wipers with the increased frequency

At a car stop screen wipers work with normal rate (it does not belong to cars with the sensor of intensity of a rain).

5. Work of stekloomyvatel in an automatic mode

Spraying of a windscreen by washing liquid is accompanied by short-term inclusion of screen wipers.

(Short-term impact on the switch lever washing liquid moves on a windscreen, but screen wipers do not join).

6. Work of stekloomyvatel in intensive режиме*

As Stekloomyvateli work as well as at installation of the lever of the switch in situation 5, but with advancing spraying of a windscreen by strong detergent.

Фароомыватели*

If devices of illumination of the car are switched on, at every fifth operation of washers of a windscreen in an automatic or intensive mode there is an automatic washing of headlights.

In order to avoid deterioration of visibility it is necessary to use washers only if freezing of washing liquid on a windscreen is excluded. Use special nonfreezing liquid (address to Specifications). In order to avoid damage of the pump of system of stekloomyvatel it cannot be included in the absence of liquid in a refueling tank.

Heating snuffled stekloomyvatel

Heating is carried out automatically if the ignition key is thus in situation 2.

Heating of back glass

Inclusion
Press a key. While the control lamp burns, heating of back glass works in a mode of the increased capacity (the accelerated defrosting).
When the lamp dies away, the capacity of heating is reduced, and its shutdown is made automatically.
If it is necessary, press a key once again. The accelerated defrosting again will be included, while the control lamp burns.
Switching off
At a burning control lamp press a key.

Multipurpose steering wheel (MFL) *

1 — Phone: to remove/hang up, begin a set, to stop conversation
2 — Radio/phone: switching
3 — Radio/phone: station search / telephone number down according to the range/list of phones
4 — Radio/phone: loudness
5 — Radio/phone: station search / telephone number up according to the range/list of phones
6 — the Sound signal, all panel
7 — Automatic equipment of maintenance of the set speed: inclusion
8 — Automatic equipment of maintenance of the set speed: input of the actual speed as set and its subsequent increase (+) or reduction of speed and input of the reached value in memory (-)
9 — Automatic equipment of maintenance of the set speed: switching off
10 — Inclusion and switching off of a mode of a retsirkulyatsiya of air or heating of a steering wheel

In a multipurpose steering wheel the keys allowing quickly are built in, without distracting from the events on the road, to use:
 • some functions of a radio receiver
 • the conditioner in a mode of a retsirkulyatsiya of air
or
 • system of heating of a steering wheel
 • automatic equipment of maintenance of the set speed
 • some functions of phone

For management of various systems from their multipurpose steering wheel it is necessary to include previously.

On an illustration the possible example of a full complete set is shown. Details contain in descriptions of concrete options.

Alarm light system

Button illumination periodically blinks at the switched-on alarm system.
At included illumination of the car the button is highlighted that allows to find easier it.